基于变分模态分解和Wigner-Ville的单向阀早期故障诊断

详细信息    查看全文 | 推荐本文 |

英文篇名：Early fault diagnosis of check valve based on variational mode decomposition and Wigner-Ville 作者：吴漫 ; 冯早 ; 黄国勇 ; 牟竹青 英文作者：WU Man;FENG Zao;HUANG Guoyong;MU Zhuqing;Faculty of Information Engineering &Automation, Kunming University of Science and Technology;Engineering Research Center for Mineral Pipeline Transportation.YN; 关键词：单向阀 ; VMD ; Wigner-Ville ; 早期故障诊断 英文关键词：check valve;;variational mode decomposition;;Wigner-Ville;;early fault diagnosis 中文刊名：SYCS 英文刊名：China Measurement & Test 机构：昆明理工大学信息工程与自动化学院;云南省矿物管道输送工程技术研究中心; 出版日期：2019-04-30 出版单位：中国测试 年：2019 期：v.45;No.249 基金：国家自然科学基金资助项目(61663017) 语种：中文; 页：SYCS201904020 页数：7 CN：04 ISSN：51-1714/TB 分类号：120-126

摘要

针对大型往复式机械设备高压隔膜泵单向阀早期故障难以识别的问题,该文提出基于变分模态分解(variational mode decomposition,VMD)和Wigner-Ville的单向阀早期故障诊断方法。首先,利用VMD将原始振动信号分解成有限个IMF分量,基于观察中心频率法筛选富含故障信息的IMF分量;然后,利用魏格纳-维利分布(Wigner-Ville distribution,WVD)对筛选后的IMF分量计算,得到每个分量的Wigner-Ville分布;最后,将各项结果线性求和得到信号的WVD分布。经仿真与工程实验分析,该方法能较好表征出振动信号中所蕴含的单向阀早期故障特征信息,能实现高压隔膜泵单向阀早期故障诊断。
        In view of the difficult identification of the early failure of large reciprocating mechanical equipment high pressure diaphragm pump check valve, an early fault diagnosis method of it that based on variational mode decomposition(VMD) and Wigner-Ville is proposed. Firstly, the original vibration signal is decomposed into a finite number of IMF components by VMD, and the IMF components rich in fault information are screened based on the observing center frequency method. Then the screened IMF components are calculated by Wigner-Ville distribution(WVD), and the Wigner-Ville distribution of each component is obtained. Finally,the results are linearly summed and the WVD distribution of the signal is obtained to extract the characteristics of the fault vibration signal. Through simulation and engineering experiment analysis, this method can better characterize the early fault characteristic information of the check valve that contained in the vibration signal,and can realize the early fault diagnosis of the high pressure diaphragm pump check valve.

引文

[1]牟伟杰,石林锁,蔡艳平,等.基于EMD-WVD与LNMF的内燃机故障诊断[J].振动与冲击,2016,35(23):191-196.
    [2]刘昱,张俊红,毕凤荣,等.基于LMD边际谱的柴油机气门故障诊断[J].内燃机工程,2014,35(6):96-100.
    [3]蔡艳平,李艾华,王涛,等.基于EMD-Wigner-Ville的内燃机振动时频分析[J].振动工程学报,2010,23(4):430-437.
    [4]JING Y B,LIU C W,BI F R,et al.Diesel engine valve clearance fault diagnosis based on features extraction techniques and fastICA-SVM[J].Chinese Journal of Mechanical Engineering,2017,30(4):991-1007.
    [5]史丽晨,段志善.基于混沌-分形理论的往复式活塞隔膜泵磨损故障分析[J].农业机械学报,2010,41(4):222-226.
    [6]马军.往复式高压隔膜泵单向阀状态监测及故障诊断研究[D].昆明:昆明理工大学,2016.
    [7]段礼祥,张来斌,王朝晖,等.往复泵泵阀故障的细化谱诊断法[J].仪器仪表学报,2004,25(S2):568-570.
    [8]段礼祥,张来斌,陈敬龙.基于Volterra级数的提升小波变换边界处理及应用[J].仪器仪表学报,2012,33(1):7-12.
    [9]徐长航,刘吉飞,陈国明,等.经验模态分解和魏格纳-维利分布在往复泵泵阀振动信号特征提取中的应用[J].中国石油大学学报(自然科学版),2010,34(3):99-10.
    [10]DRAGOMIRETSKIY K,ZOSSO D.Variational mode decomposition[J].IEEE Transactions on Signal Processing,2014,62(3):531-544.
    [11]杨宏权,张金伟.往复式活塞隔膜泵单向阀故障自动诊断技术[J].科技资讯,2012(7):116-117.
    [12]WANG Y,XU D,GE J,et al.Rolling bearing faults diagnostics based on SPWVD time-frequency distribution image texture feature[J].Journal of Vibration,Measurement and Diagnosis,2017,37(1):115-117.
    [13]刘长良,武英杰,甄成刚.基于变分模态分解和模糊C均值聚类的滚动轴承故障诊断[J].中国电机工程学报,2015,35(13):3358-3365.
    [14]唐贵基,王晓龙.参数优化变分模态分解方法在滚动轴承早期故障诊断中的应用[J].西安交通大学学报,2015,49(5):73-81.
    [15]唐贵基,王晓龙.变分模态分解方法及其在滚动轴承早期故障诊断中的应用[J].振动工程学报,2016,29(4):638-648.